1.西华大学 机械工程学院, 四川 成都 610039
祁岩(1995— ),男,河北三河人,硕士研究生;研究方向为机械设计与传动。
柳在鑫(1978— ),男,湖北黄梅人,副教授,硕士生导师,博士;研究方向为机械设计与传动。
扫 描 看 全 文
祁岩,廖鸿辉,汪旭东等.粗糙度对滚柱包络端面蜗杆传动的等温弹流润滑影响[J].机械传动,2022,46(09):36-41.
Qi Yan,Liao Honghui,Wang Xudong,et al.Influence of Roughness on Isothermal Elastohydrodynamic Lubrication of Roller Enveloped Worm Drive[J].Journal of Mechanical Transmission,2022,46(09):36-41.
祁岩,廖鸿辉,汪旭东等.粗糙度对滚柱包络端面蜗杆传动的等温弹流润滑影响[J].机械传动,2022,46(09):36-41. DOI: 10.16578/j.issn.1004.2539.2022.09.005.
Qi Yan,Liao Honghui,Wang Xudong,et al.Influence of Roughness on Isothermal Elastohydrodynamic Lubrication of Roller Enveloped Worm Drive[J].Journal of Mechanical Transmission,2022,46(09):36-41. DOI: 10.16578/j.issn.1004.2539.2022.09.005.
基于滚柱包络端面蜗杆传动副的啮合原理,综合考虑中心距、滚柱半径、喉颈系数、蜗轮直径各项几何参数的影响,根据弹性流体动压润滑理论,在Matlab中采用牛顿迭代法和Newton-Raphson法对其数值计算求解,对该新型传动副共轭齿进行研究,完成了共轭齿间线接触问题的分析;给出了该传动副共轭齿面在几何参数变化下,粗糙度幅度值大小变化下的润滑油膜压力和油膜厚度示意图,并进行了分析。结果表明,该传动副性能较好,影响润滑的重要参数为滚柱半径与啮合位置,而喉颈系数和蜗轮直径参数对润滑特性影响不大;共轭齿面间能够产生全膜润滑,避免发生直接接触,减小磨损量并降低油温,能够同时提升传动效率与抗胶合能力。为该新型传动副的研制提出了必要的理论依据。
Based on the meshing principle of the roller enveloped end face worm drive pair, the influence of the center distance, the roller radius, the throat coefficient, and the worm gear diameter are considered comprehensively. According to the elastohydrodynamic lubrication theory, the Newton iteration method is used in Matlab. The Newton-Raphson method is used to solve its numerical calculation, the conjugate teeth of the new transmission pair are studied, and the analysis of the line contact between the conjugate teeth is completed. The schematic diagram of lubricating oil film pressure and oil film thickness under the change of geometric parameters and roughness amplitude of the conjugate tooth surface of the transmission pair is given, and the analysis is completed. The results show that the performance of the transmission pair is good. The important parameters affecting the lubrication are the roller radius and the meshing position, while the throat coefficient and the worm gear diameter have little effect on the lubrication characteristics. Full-film lubrication can be generated between the conjugated tooth surfaces to avoid direct contact, reduce wear and oil temperature, and improve transmission efficiency and anti-glue ability at the same time. Therefore, the necessary theory and application value are given for the development of the new transmission pair.
滚柱粗糙度弹流润滑油膜压力油膜厚度
RollerRoughnessElastohydrodynamic lubricationOil film pressureOil film thickness
CHEN Y H,ZHANG G H,CHEN B K,et al.A novel enveloping worm pair via employing the conjugating planar internal gear as counterpart[J].Mechanism & Machine Theory,2013,67:17-31.
廖鸿辉,柳在鑫,李玲玉,等.单滚子包络端面蜗杆传动接触及自转分析[J].机械强度,2021,43(4):897-905.
LIAO Honghui,LIU Zaixin,LI Lingyu,et al.Contact and rotation analysis of single roller enveloping face worm drive[J].Journal of Mechanical Strength,2021,43(4):897-905.
尹昌磊,杨沛然,杨萍.线接触弹流润滑综合数值分析[J].润滑与密封,2006(9):70-73.
YIN Changlei,YANG Peiran,YANG Ping.General analysis of line contact elastohydrodynamic lubrication[J].Lubrication Engineering,2006(9):70-73.
许立忠,杨育林,黄真.超环面行星蜗杆传动弹流润滑状态研究[J].机械工程学报,2002(9):114-117.
XU Lizhong,YANG Yulin,HUANG Zhen.EHD condition for toroidal drive[J].Journal of Mechanical Engineering,2002(9):114-117.
SHARIF K J,KONG S,EVANS H P,et al.Contact and elastohydrodynamic analysis of worm gears,Part 1:theoretical formulation[J].Proceedings of the Institution of Mechanical Engineers Part C:Journal of Mechanical Engineering Science,2001,215(C7):817-830.
汪久根,朱聘和.蜗杆传动的润滑分析[J].润滑与密封,2005(1):3-4.
WANG Jiugen,ZHU Pinhe.Study on lubrication in worm gear transmission[J].Lubrication Engineering,2005(1):3-4.
邱昕洋,张光辉,秦大同.钢制平面蜗轮传动弹流润滑分析[J].重庆大学学报,2010,33(3):24-29.
QIU Xinyang,ZHANG Guanghui,QIN Datong.Analysis of elastohydrodynamic lubrication of steel planar wormgear drive[J].Journal of Chongqing University,2010,33(3):24-29.
王小龙.滚柱包络端面啮合蜗杆传动闪温特性分析[J].机械传动,2020,44(10):148-153.
WANG Xiaolong.Analysis of flash temperature characteristic of the roller enveloping end face engagement worm drive[J].Journal of Mechanical Transmission,2020,44(10):148-153.
柳在鑫,王进戈,张均富,等.交错轴双滚子包络环面蜗杆传动啮合分析[J].工程科学与技术,2012,44(4):221-225.
LIU Zaixin,WANG Jin'ge,ZHANG Junfu,et al.Meshing analysis of non-parallel double-roller enveloping hourglass worm gearing[J].Advanced Engineering Sciences,2012,44(4):221-225.
陈尚友.无侧隙滚柱包络端面啮合蜗杆传动建模与研究[D].成都:西华大学,2015:20-22.
CHEN Shangyou.A modeling and study of non-backlash roller enveloping end meshing worm gearing[D].Chengdu:Xihua University,2015:20-22.
温诗铸,杨沛然.弹性流体动力润滑[M].北京:清华大学出版社,1993:15-16,69-72,94-99.
WEN Shizhu,YANG Peiran.Elastohydrodynamic lubrication[M].Beijing:Tsinghua University Press,1993:15-16,69-72,94-99.
李金宽,柳在鑫,张翠.倾斜式双圆柱滚子包络环面蜗杆传动的等温弹流润滑分析[J].西安交通大学学报,2017,51(5):88-94.
LI Jinkuan,LIU Zaixin,ZHANG Cui.Analysis on isothermal elastohydrodynamic lubrication performance of inclined double-roller enveloping hourglass worm drive[J].Journal of Xi'an Jiaotong University,2017,51(5):88-94.
黄平.润滑数值计算方法[M].北京:高等教育出版社,2012:150-162.
HUANG Ping.Lubrication numerical calculation methods[M].Beijing:Higher Education Press,2012:150-162.
王小龙.滚柱包络端面啮合蜗杆传动弹流润滑分析[J].机械传动,2020,44(9):128-132.
WANG Xiaolong.Contact and rotation anlysis of single roller enveloping face worm drive[J].Journal of Mechanical Transmission,2020,44(9):128-132.
DENG X Q,WANG J L,WANG J G,et al.Parametric analysis of the end face engagement worm gear[J].Chinese Journal of Mechanical Engineering,2015,28(6):1177-1185.
杨捷,王进戈,陈守安,等.无侧隙平面一次包络端面啮合环面蜗杆副弹流润滑分析[J].西安交通大学学报,2017,51(3):87-91.
YANG Jie,WANG Jin'ge,CHEN Shouan,et al.Analysis on elastohydrodynamic lubrication of the planar enveloped toroidal worm in anti-backlash endface meshing[J].Journal of Xi'an Jiaotong University,2017,51(3):87-91.
李金宽,柳在鑫,李世蓉,等.倾斜式双滚柱包络环面蜗杆传动弹流润滑分析[J].西安交通大学学报,2018,52(3):83-90.
LI Jinkuan,LIU Zaixin,LI Shirong,et al.Analysis of elastohydrodynamic lubrication of inclined double-roller enveloping hourglass worm drive[J].Journal of Xi'an Jiaotong University,2018,52(3):83-90.
0
浏览量
3
下载量
0
CSCD
关联资源
相关文章
相关作者
相关机构