Research on the Influence of Rotational Speed on the Noise of V-ribbed Belt Three-wheel Drive System

Xuecheng Zhang; Zhendong Jiang; Yaochen Shi; Tianxiang Zhao

doi:10.16578/j.issn.1004.2539.2021.10.007

您当前的位置：

首页 >

文章列表页 >

Research on the Influence of Rotational Speed on the Noise of V-ribbed Belt Three-wheel Drive System

Theory·Reserach | 更新时间：2022-11-10

- Research on the Influence of Rotational Speed on the Noise of V-ribbed Belt Three-wheel Drive System
- Journal of Mechanical Transmission Vol. 45, Issue 10, Pages: 47-50(2021)
- 作者机构：
  
  1.长春理工大学机电工程学院，吉林长春 130022
  2.长春光华学院机械工程学院，吉林长春 130033
  3.长春大学机械与车辆工程学院，吉林长春 130022
- 作者简介：
- 基金信息：
- DOI：10.16578/j.issn.1004.2539.2021.10.007
  CLC：
扫描看全文
张学忱,姜振东,史尧臣等.转速对多楔带三轮传动系统噪声的影响规律研究[J].机械传动,2021,45(10):47-50.

Zhang Xuecheng,Jiang Zhendong,Shi Yaochen,et al.Research on the Influence of Rotational Speed on the Noise of V-ribbed Belt Three-wheel Drive System[J].Journal of Mechanical Transmission,2021,45(10):47-50.
张学忱,姜振东,史尧臣等.转速对多楔带三轮传动系统噪声的影响规律研究[J].机械传动,2021,45(10):47-50. DOI： 10.16578/j.issn.1004.2539.2021.10.007.

Zhang Xuecheng,Jiang Zhendong,Shi Yaochen,et al.Research on the Influence of Rotational Speed on the Noise of V-ribbed Belt Three-wheel Drive System[J].Journal of Mechanical Transmission,2021,45(10):47-50. DOI： 10.16578/j.issn.1004.2539.2021.10.007.

摘要

为了研究转速对多楔带三轮传动系统噪声大小的影响规律，以6PK多楔带为例，基于声阵列原理搭建了多楔带三轮传动系统噪声测试试验装置，得到了不同转速下三轮传动系统中声压的时域信号和噪声声压分布云图。随着转速的增加，多楔带三轮传动系统中的噪声大小逐渐增加。多楔带横向振动引起的低频噪声随着转速的增加逐渐增大，通过多普勒激光测振仪测量得出多楔带横向振动噪声的增加是由于多楔带横向振动幅值的增大引起的；通过噪声声压云图可以看出，多楔带与带轮之间摩擦引起的高频摩擦噪声大小随着转速的增加而增大；当多楔带三轮传动系统发生共振时，传动系统的噪声明显增加。

Abstract

In order to study the influence of speed on the noise level of the V-ribbed belt three-wheel drive system，taking the 6PK V-ribbed belt as an example，a noise test device for the three-wheel drive system of the V-ribbed belt is built based on the acoustic array principle，and the time-domain signal and noise sound pressure distribution cloud diagram of the sound pressure in the transmission system of three wheels at different speeds are obtained. As the rotation speed increases，the noise in the V-belt three-wheel drive system gradually increases. The low-frequency noise caused by the lateral vibration of the V-ribbed belt gradually increases with the increase of the speed. The increase in the lateral vibration noise of the V-ribbed belt is measured by the Doppler laser vibrometer is caused by the increase in the amplitude of the lateral vibration of the V-ribbed belt. It can be seen from the noise sound pressure cloud diagram that the high frequency friction noise caused by the friction between the V-ribbed belt and the pulley increases with the increase of the speed，when the three-wheel drive system of the V-ribbed belt resonates，the transmission system the noise has increased significantly.

关键词

多楔带横向振动噪声

Keywords

V-ribbed beltLateral vibrationNoise

references

任国强，黄杰东.多楔带传动系统带速损失实验研究［J］.机械传动，2015，39（11）：132-134.

REN Guoqiang，HUANG Jiedong.Experimental study on belt speed loss of multi-wedge drive system［J］.Journal of Mechanical Transmission，2015，39（11）：132-134.

吴贻珍.传动带新产品研究进展［J］.机械传动，2013，37（8）：4-9.

WU Yizhen.Research progress of new belt products［J］.Journal of Mechanical Transmission，2013，37（8）：4-9.

徐劲力，潘青姑，陈端滢.基于汽车NVH提升的传动轴优化仿真分析与实验验证［J］.汽车工程，2018，40（12）：1467-1474.

XU Jinli，PAN Qinggu，CHEN Duanying.Simulation analysis and experimental verification of transmission shaft optimization based on automotive NVH lift［J］.Automotive Engineering，2012，40（12）：1467-1474.

郝耀东，潘能贵，何智成，等.基于阻尼特性鲁棒性的车身NVH性能设计［J］.振动与冲击，2018，37（19）：139-145.

HAO Yaodong，PAN Nenggui，HE Zhicheng，et al.Body NVH performance design based on robustness of damping characteristics［J］.Vibration and Impact，2012，37（19）：139-145.

DALGARNO K W，MOORE R B，DAY A J.Tangential slip noise of V-ribbed belts［J］.Proceedings of the Institution of Mechanical Engineers，Part C：Journal of Mechanical Engineering Science，1999，213（7）：741-749.

SHENG G，LIU K M，OTREMBA J，et al.A model and experimental investigation of belt noise in automotive accessory belt drive system［J］.International Journal of Vehicle Noise and Vibration，2004（1）：68-82.

SHENG G.A Study of drying-up friction and noise of automotive accessory belt［J］.SAE International Journal of Passenger Cars-Mechanical Systems，2013，6（2）：1066-1069.

唐武生，宁凯，史尧臣，等.汽车多楔带摩擦噪声机理分析与试验研究［J］.机械传动，2020，44（1）：122-124.

TANG Wusheng，NING Kai，SHI Yaochen，et al.Mechanism analysis and experimental study on friction noise of automobile multi-wedge belt［J］.Journal of Mechanical Transmission，2020，44（1）：122-124.

杨许刚.汽车多楔带横向振动与噪声的研究［D］.长春：长春理工大学，2018：58-61.

YANG Xugang.Research on lateral vibration and noise of multi-ribbed belts［D］.Changchun：Changchun University of Science and Technology，2018：58-61.

史尧臣，陈国平，周鹏，等.汽车多楔带传动噪声仿真分析与试验验证［J］.机械传动，2020，44（8）：46-51.

SHI Yaochen，CHEN Guoping，ZHOU Peng，et al.Simulation analysis and test verification of automobile multi-wedge belt transmission noise［J］.Journal of Mechanical Transmission，2020，44（8）：46-51.

王红云，曾祥坤，向英，等.基于振动控制的多楔带附件驱动系统优化［J］.振动与冲击，2016，35（13）：201-205.

WANG Hongyun，ZENG Xiangkun，XIANG Ying，et al.Optimization of multi-wedge belt accessory drive system based on vibration control［J］.Vibration and Impact，2016，35（13）：201-205.

上官文斌，张智，许秋海.多楔带传动系统轮——带振动的实测与计算方法研究［J］.机械工程学报，2011，47（21）：28-36.

SHANGGUAN Wenbin，ZHANG Zhi，XU Qiuhai.Study on the measurement and calculation method of the wheel-belt vibration of the multi-ribbed belt transmission system［J］.Chinese Journal of Mechanical Engineering，2011，47（21）：28-36.

郭建华，姜洪源，孟庆鑫，等.新型人字齿同步带噪声、振动试验研究［J］.振动与冲击，2015，34（17）：120-123.

GUO Jianhua，JIANG Hongyuan，MENG Qingxin，et al.Experimental study on noise and vibration of a new type of herringbone tooth synchronous belt［J］.Vibration and Impact，2015，34（17）：120-123.

劳耀新，侯之超，吕振华.发动机前端附件带传动系统频率灵敏度分析［J］.汽车工程，2006（5）：477-481.

LAO Yaoxin，HOU Zhichao，LÜ Zhenhua.Frequency sensitivity analysis of engine front accessory belt drive system［J］.Automotive Engineering，2006（5）：477-481.

郜雪鹏.某航空发动机附件传动系统的共振特性分析［J］.机械传动，2016，40（3）：127-130.

GAO Xuepeng.Analysis of resonance characteristics of an aero-engine accessory transmission system［J］.Journal of Mechanical Transmission，2016，40（3）：127-130.

郭建华，张广彬，胡清明，等.同步带啮合传动的空气传播对噪声影响实验研究［J］.机械传动，2015，39（10）：93-96.

GUO Jianhua，ZHANG Guangbin，HU Qingming，et al.Experimental study on the influence of air propagation on noise of synchronous belt meshing transmission［J］.Journal of Mechanical Transmission，2015，39（10）：93-96.

史尧臣，陈国平，李占国，等.三轮一带传动系统噪声仿真与试验验证［J］.西安交通大学学报，2019，53（8）：76-81.

SHI Yaochen，CHEN Guoping，LI Zhanguo，et al.Noise simulation and experimental verification of three-wheel drive system［J］.Journal of Xi'an Jiaotong University，2019，53（8）：76-81.

李利平，李广龙，上官文斌，等.自动张紧器固有频率测试探索性实验研究［J］.实验技术与管理，2017，34（9）：60-63.

LI Liping，LI Guanglong，SHANGGUAN Wenbin，et al.Exploratory experimental research on natural frequency test of automatic tensioner［J］.Experimental Technology and Management，2017，34（9）：60-63.

Views

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Influence of Gear Helix Angle on Noise of Door Controlled Reducer

Simulation and Experimental Study on a Silent Chain of Automobile Transmission Oil Pump

Analysis and Experimental Study of Automotive Synchronous Belt Transmission Noise

NVH Simulation Research and Optimization of Electric Vehicle Reducer

Analysis of the Influence of Load Transmission Error on the Vibration Characteristic of Spiral Bevel Gear based on MASTA Simulation

Related Author

No data

Related Institution

School of Mechanical and Energy Engineering， Zhejiang University of Science and Technology

Qingdao Choho Industrial Co.，Ltd.

Mechanical and Power Engineering College， Yingkou Institute of Technology

School of Automobile and Transportation， Shenyang Ligong University

School of Intelligent Manufacturing and Automotive Engineering， Guang'an Vocational & Technical College

⁰